check out the new remote control Jockey Wheel SmartBar rearview170 Topargee products Enginesaver Low Water Alarms
Members Login
Username 
 
Password 
    Remember Me  
Click here for the Grey Nomads website -> The Grey Nomads Forum -> Techies' Corner -> Eberspacher won't start
Post Info TOPIC: Eberspacher won't start
Stl


Senior Member

Status: Offline
Posts: 124
Date:
Eberspacher won't start
Permalink  

Hi, I've checked all previous posts but, my D2 ( only been used for at the most 6 hours) stopped working and now won't start, blows white smoke. I've replaced the glow plug, glow plug screen, cleaned the filter on the pump and replaced the inline fuel filter as well. I've stripped it completely down and no carbon, vent to glow plug good. Drained the diesel and have even tried it on kero... Power at the heater ( I spiked into the lume) was 13.4 volt and when trying to start dropped down to 12.9 volt... at the glow plug which "you" can only test when trying to start is 5.6 volts.  So far no caravan dealer or Eberspacher maintenance dealers can tell me what voltage should be at the glow plug..  any ideas? And is there a caravan maintenance outlet on the Sunshine Coast that has the equipment to plug into it, the fault code is only coming up Err, no code. Everyone I've spoken to say bring the van  in and we'll have a look but they don't have a computer to fault find..



__________________

Just another day closer to dying...MAKE THE MOST OF IT.  :))
Bill B


Guru

Status: Offline
Posts: 2689
Date:
Permalink  

Try this site for info on various faults : www.letonkinoisvarnish.uk/eberspacher_faults_1.html

__________________
Bill B
Stl


Senior Member

Status: Offline
Posts: 124
Date:
Permalink  

Thanks Bill, that's the best site that I have seen so far, have done everything except  check the ohms ,  which I will now do.  Len.  



__________________

Just another day closer to dying...MAKE THE MOST OF IT.  :))
Peter_n_Margaret


Guru

Status: Offline
Posts: 4375
Date:
Permalink  

Eberspächer (UK) Ltd.
Climate House
Yeoman Road
Ringwood, Hampshire BH24 3FA

Phone: +44 1425 480151
Fax: +44 1425 480152
enquiries[at]eberspaecher.com

Cheers,
Peter

__________________

OKA196, 4x4 'C' Class, DIY, self contained motorhome. 960W of solar, 400Ah of AGMs, 310L water, 280L fuel. https://www.oka4wd.com/forum/members-vehicles-public/569-oka196-xt-motorhome
 

 
nomadz


Veteran Member

Status: Offline
Posts: 45
Date:
Permalink  

Hi, 

Not the Sunshine Coast but give Caboolture Caravan Repairs a call On 07 54951966. I think they are Eberspacher service agents and they are normally very good at everything they do. We have used them for various caravan services/repairs over the years and always been well satisfied.

Regards,

Ian



__________________
You don't have to know everything, you just have to know someone who does!
PeterInSa


Guru

Status: Offline
Posts: 1046
Date:
Permalink  

Have you tried to start the heater with the inlet air hose and the exhaust hose not connected, could well be a blockage in one/both of these hoses.

__________________
Stl


Senior Member

Status: Offline
Posts: 124
Date:
Permalink  

HI, yes exhaust and inlet disconnected, they were the first things I did, then changed fuel, then new glow plug screen, then new glow plug, then pulled whole unit apart checked air inlet for glow plug and no carbon in chamber ( like brand new).

len. 



__________________

Just another day closer to dying...MAKE THE MOST OF IT.  :))
PeterInSa


Guru

Status: Offline
Posts: 1046
Date:
Permalink  

Blows white smoke, to me its an ignition problem since inlet has been disconnected.

When I had a similar problem and under advice from a Heater Org, I tested out the glow plug and firing circuit. In the rebuild I had earthed a wire or open circuit a wire.



-- Edited by PeterInSa on Tuesday 12th of January 2021 04:49:25 PM

__________________
Jaybird


Veteran Member

Status: Offline
Posts: 64
Date:
Permalink  

You could have a look at this group. It is for the Chinese knockoff diesel heaters and I have read of similar issues here.
www.facebook.com/groups/146837062640024

__________________

Living on the Gippsland Lakes Victoria.
Bas + Eve


Senior Member

Status: Offline
Posts: 459
Date:
Permalink  

Dieselheat.com.au they are fabulous and have a very good troubleshooting page. You can call them and they are helpful and polite. They will talk you through everything.

__________________
Nifty150


Veteran Member

Status: Offline
Posts: 32
Date:
Permalink  

I cant really help, but dont lose heart. Our D2 bought in 2003 ($1800) has run in a boat for 6 years, a caravan for 6 years, and a motorhome for 5 years, and has received no maintenance and suffered no faults. I hope yours will be the same when you get it going...

__________________
Tony LEE


Guru

Status: Offline
Posts: 654
Date:
Permalink  

Can be sensitive to low voltage. Check voltage at heater while start cycle is running

__________________
Page 1 of 1  sorted by
 
Quick Reply

Please log in to post quick replies.
Click here for the Grey Nomads website -> The Grey Nomads Forum -> Techies' Corner -> Eberspacher won't start
Tweet this page Post to Digg Post to Del.icio.us
Purchase Grey Nomad bumper stickers Read our daily column, the Nomad News The Grey Nomad's Guidebook