check out the new remote control Jockey Wheel SmartBar rearview170 Topargee products Enginesaver Low Water Alarms
Members Login
Username 
 
Password 
    Remember Me  
Click here for the Grey Nomads website -> The Grey Nomads Forum -> Techies' Corner -> Leaking roof - Winnebago Esperance
Post Info TOPIC: Leaking roof - Winnebago Esperance
FraLyn


Veteran Member

Status: Offline
Posts: 31
Date:
Leaking roof - Winnebago Esperance
Permalink  

We have an intermittent leaking roof.  Leaks appear around the air conditioning unit and the sky light areas though not all the time no.  Can anyone suggest a solution or experienced similar problems or suggest a reputable EPDM roof repairer in Sydney?.  Thanks

FraLyn



__________________
woolman


Guru

Status: Offline
Posts: 547
Date:
Permalink  

We have a Winnebago Explorer I believe has similar hatch. The problem with mine was the original installation. From inside when you take off the trims and remove internal fittings (not hard, just screws) you will find the screws holding the top section down. The correct method of securing is using 3/32 threaded bolts. Winnebago in their wisdom use tek screws that are too short (would have busted up the plastic if longer), which is fortunate because only 3 of the 16 actually attached at all to top section (albiet by only 1 thread) therefore not damaging the internal threads. Because of the thickness of the roof I was not able to obtain off the shelf bolts to do the job. I purchased a length of rod, cut to length and used a dome nuts to fix in place. It all works and water proof now. I have no idea how the hatch stayed in place, obviously only the stickyness of the foam sealing tape that actually held hatch in place  for 5 years. 

Good luck

 

Neil

 



__________________
Aus-Kiwi


Guru

Status: Offline
Posts: 7642
Date:
Permalink  

There's the guys out Avida Head Office

32 David Road
Emu Plains NSW 2750
Australia

PO Box 420
Emu Plains NSW 2750
Australia

Phone: 02 4735 8116
Fax: 02 4735 8070

www.avidarv.com.au


Read more at www.avidarv.com.au/contact-us

Who could do it for you .. ?
I

__________________
Whats out there
woolman


Guru

Status: Offline
Posts: 547
Date:
Permalink  

Aus-Kiwi wrote:

There's the guys out Avida Head Office

32 David Road
Emu Plains NSW 2750
Australia

PO Box 420
Emu Plains NSW 2750
Australia

Phone: 02 4735 8116
Fax: 02 4735 8070

www.avidarv.com.au


Read more at www.avidarv.com.au/contact-us

Who could do it for you .. ?
I

 my concern would be if they would repair any better than the original build. By the way, Winnebago aren't the only company that don't instal things according to instructions.

 

Neil



__________________
Aus-Kiwi


Guru

Status: Offline
Posts: 7642
Date:
Permalink  

Shoot the messenger.. If it was there fopar they can fix it.. It's an option ...


__________________
Whats out there
Possum3


Guru

Status: Offline
Posts: 8739
Date:
Permalink  

I've had my Avida back to them 5 times to fix a leak and other poor workmanship under warranty - they take weeks and it comes back still leaking

__________________

Possum; AKA:- Ali El-Aziz Mohamed Gundawiathan

Sent from my imperial66 typewriter using carrier pigeon, message sticks and smoke signals.
Aus-Kiwi


Guru

Status: Offline
Posts: 7642
Date:
Permalink  

Is it condensation from unit ? There is a rubber paint which can apply to keep EPDM in top condition..
Check YouTube ... But the rubber must be sealed first .. Water leaks can be pita to find and cure ..

__________________
Whats out there
FraLyn


Veteran Member

Status: Offline
Posts: 31
Date:
Permalink  

Thank you all for your replies. I will be doing some more research prior to proceeding with the next step.
FraLyn

__________________
Marlene6


Member

Status: Offline
Posts: 15
Date:
Permalink  

Avida Birdsville 2020 bought new in July. Rain comes in through air-conditioning onto our bed Third time back to dealer and still leaking. Haven't been able to use it since first rain in WA Anyone else? any suggestions?

__________________
marlene fuller
KFT


Guru

Status: Offline
Posts: 2437
Date:
Permalink  

Marlene6 wrote:

Avida Birdsville 2020 bought new in July. Rain comes in through air-conditioning onto our bed Third time back to dealer and still leaking. Haven't been able to use it since first rain in WA Anyone else? any suggestions?

 Hi you have tacked on to the end of a very old thread.

You may get a better response if you start a new topic

Frank



__________________

Avagreatday.

Kathy and Frank currently at Home near Quirindi NSW
montie


Guru

Status: Offline
Posts: 1081
Date:
Permalink  

FraLyn wrote:

We have an intermittent leaking roof.  Leaks appear around the air conditioning unit and the sky light areas though not all the time no.  Can anyone suggest a solution or experienced similar problems or suggest a reputable EPDM roof repairer in Sydney?.  Thanks

FraLyn

 If it's a Winnebago Esperance it is at least 5/6 years old..

I would suggest you take it to a good repair centre and have all your roof sealants checked.



__________________

Monty. RV Dealer.
Aus-Kiwi


Guru

Status: Offline
Posts: 7642
Date:
Permalink  

Get Similar colour Sikoflex and go around joints . It self levels, seals . Put it over screws etc . Dont worry it doesnt look ugly ! Cant be seen . Then paint area for better UV protection .,

__________________
Whats out there
Bill B


Guru

Status: Offline
Posts: 2689
Date:
Permalink  

montie wrote:

If it's a Winnebago Esperance it is at least 5/6 years old..

I would suggest you take it to a good repair centre and have all your roof sealants checked.




Original post is dated 14/11/2015

__________________
Bill B
PeterD


Guru

Status: Offline
Posts: 4730
Date:
Permalink  

Frank (FraLyn) has not been around since 10:39 Mar 19, 2018, no good addressing him.



__________________

PeterD
Nissan Navara D23 diesel auto, Spaceland pop-top
Retired radio and electronics technician.
NSW Central Coast.

 
Page 1 of 1  sorted by
 
Quick Reply

Please log in to post quick replies.
Click here for the Grey Nomads website -> The Grey Nomads Forum -> Techies' Corner -> Leaking roof - Winnebago Esperance
Tweet this page Post to Digg Post to Del.icio.us
Purchase Grey Nomad bumper stickers Read our daily column, the Nomad News The Grey Nomad's Guidebook